UK Buell Enthusiasts Group
https://ukbeg.com/forum/

XB starter motor or battery problem?
https://ukbeg.com/forum/viewtopic.php?f=8&t=21341		 Page 1 of 1
Author:  thecoldplace [ 10 Apr 2016 16:58 ]
Post subject:  XB starter motor or battery problem?
Dear Buell people!!

Having a bit of a starting issue with my 2007 XB12X thingy.

For a while now (end of last year and into this) if I didn't have the battery fully charged I got a clicking from the starter and struggling to turn the engine over. It helped if I left the charger connected to start the bike initially. If I was out for a run, usually fine. I just thought good slug of charge from the alternator and warm engine meant the battery could then cope.

As the battery is original, and the symptoms so far, I assumed the battery was getting toward being buggered rather than anything else, so ordered and fitted a new Motobatt glass mat impregnated thing, as had heard/read good reviews.

The problem with starting is exactly the same as before, possibly worse with the new battery fitted, aaargh!

Could the fault be with the starter motor and the battery is actually fine?

Is there a possibility of it just being the starter motor clutch, if so are they rebuildable?

If it is the starter motor how much and what is the best source?

Many thanks

Pat
Author:  Maz [ 10 Apr 2016 17:59 ]
Post subject:  Re: XB starter motor or battery problem?
Have you lost my number ? :roll:
Author:  thecoldplace [ 10 Apr 2016 18:15 ]
Post subject:  Re: XB starter motor or battery problem?
Cooooeeee sweetpea!!!

Didn't want to trouble you on a Sunday :-)

Glad to hear you are all set up again as The Emporium, will have to scuttle up for a visit soon....

From the address are you now in the Mill to the left (looking from the road) of the Mill you used to be in?
Author:  Maz [ 10 Apr 2016 18:27 ]
Post subject:  Re: XB starter motor or battery problem?
There never was any mills to the left (looking from the road) ! :?
I'm 300 yards further down the road on the same side ie. next door but one :)
Author:  pash [ 10 Apr 2016 18:34 ]
Post subject:  Re: XB starter motor or battery problem?
What happens if you put a jump lead from the battery -ve to the engine?
Author:  marcus_asparagus [ 10 Apr 2016 19:21 ]
Post subject:  Re: XB starter motor or battery problem?
Might be worth checking that hateful connector 77 down under the pulley cover hasn't melted and stopping your battery charging from the engine?

Do you get the full 14.2 volts at the battery with the engine running?

Worth a quick check anyway.

Good luck, Mark.
Author:  thecoldplace [ 10 Apr 2016 22:11 ]
Post subject:  Re: XB starter motor or battery problem?
Thanks for the suggestions Nick and Mark, will give both a try and report back.......
Author:  barney [ 12 Apr 2016 09:13 ]
Post subject:  Re: XB starter motor or battery problem?
You are only about an hour to an hour and a half from :maz:
it would make sense to go see the oracle :idea: :worthy:
Author:  thecoldplace [ 17 Apr 2016 09:30 ]
Post subject:  Re: XB starter motor or battery problem?
barney wrote:
You are only about an hour to an hour and a half from :maz:
it would make sense to go see the oracle :idea: :worthy:


Absolutely!

BTW for Nick and Mark:
Jump lead from battery -ve to engine itself, no difference.
14.2V at battery terminals with engine running.
Author:  Goofy185 [ 22 Apr 2016 06:35 ]
Post subject:  Re: XB starter motor or battery problem?
Try voltage drop from battery + to starter motor + should show zero volts then battery - to starter body should show zero volts this is done while cracking it's more accurate than checking the resistance!
Author:  Goofy185 [ 22 Apr 2016 06:36 ]
Post subject:  Re: XB starter motor or battery problem?
How many volts at battery while cranking?
Author:  Nutah [ 22 Apr 2016 20:28 ]
Post subject:  Re: XB starter motor or battery problem?
viewtopic.php?f=17&t=146
Page 1 of 1 All times are UTC
Powered by phpBB® Forum Software © phpBB Limited
https://www.phpbb.com/